Winston
Lorenzo von Matterhorn
- Joined
- Jan 31, 2009
- Messages
- 9,560
- Reaction score
- 1,749
13 MORE Things That Saved Apollo 13 (link to entire series)
April 7, 2015
https://www.universetoday.com/119747/13-more-things-that-saved-apollo-13/
13 Things That Saved Apollo 13, Part 5: Unexplained Shutdown of the Saturn V Center Engine
https://www.universetoday.com/62672...ained-shutdown-of-the-saturn-v-center-engine/
What happened was the Saturn V rocket experienced dangerous so-called “pogo” thrust oscillations, a problem NASA knew about. While a fix had been planned for Apollo 14, time did not permit its implementation on Apollo 13’s Saturn V.
“While a clerical error caused Apollo 13’s oxygen tank to explode,” said Woodfill, “because its heater design had not been updated for 65 volt operation, and the tank was a virtual bomb (see Part 1), similarly NASA’s failure to fix a known serious booster flaw should have destroyed Apollo 13.”
The Saturn V rocket had five J-2 engines, each producing 200,000 pounds of thrust, together creating the 1 million pounds of thrust needed for a mission to the Moon.
On previous Saturn flights, these pogo oscillations had occurred during launch. The phenomenon occurred as the fuel lines and structure of the rocket resonated at a common frequency. The resonance tended to amplify in force and potential destruction with each bounce of the “pogo” mechanism. So damaging was the phenomena on the unmanned Apollo 6 mission that an entire outer panel of the Saturn 5 ejected into space.
“The oscillations are like a jack hammer and it was so dreadful on Apollo 6 that it tore off a panel on the booster, and threatened the mission,” said Woodfill. “Apollo 6’s orbit was supposed to be circular, but because of the pogo effect and failure of second stage engines, the orbit became an elongated orbit of about 60 by 180 miles.”
Woodfill said if Apollo 13 had ended up in that type of orbit, it would have been bad but not fatal. However, Apollo 13 was a much different situation than Apollo 6.
The Apollo 6 mission carried a mock lunar lander of more modest mass than the “full-up” lander which Apollo 13 carried to orbit. With the added mass for Apollo 13, the pogo forces were suddenly a magnitude greater in intensity. A mission report said that the engine experienced 68g vibrations at 16 hertz, flexing the thrust frame by 3 inches (76 mm).
Woodfill said that if the center engine had continued running a few more seconds, the oscillations may have destroyed the vehicle. “That engine was pounding horizontally up and down, a quarter foot, at the rate of 16 times a second,” he said. “The engine had become a two ton sledge hammer, a deadly pogo stick of destruction, putting enormous forces on the supporting structures.”
What shut the engine down?
“It is, to this day, not fully understood, but it had something to do with fooling the engine’s thrust chamber pressure sensor that pressure was too low,” said Woodfill. He has studied the mission report, but says the complete analysis of why the engine shut down isn’t included.
“Though the shutdown command came from a low thrust chamber pressure sensor assessment, actually, the engine was operating correctly,” he said. ” The sensor had nothing to do with the pogo phenomenon. For some inexplicable reason, it was like something sucked the pressure out of the chamber and a sensor turned the engine off. But no one knows exactly why.”
Woodfill said those who later examined the situation said it was altogether lucky that the sensor shut down the engine. “Something intervened, stopping the engine from pounding its way from the mount into the fragile fuel tanks. This would have destroyed the Apollo 13 launch vehicle.”
13 MORE Things That Saved Apollo 13, part 6: The Mysterious Longer-Than-Expected Communications Blackout
https://www.universetoday.com/11992...longer-than-expected-communications-blackout/
April 7, 2015
https://www.universetoday.com/119747/13-more-things-that-saved-apollo-13/
13 Things That Saved Apollo 13, Part 5: Unexplained Shutdown of the Saturn V Center Engine
https://www.universetoday.com/62672...ained-shutdown-of-the-saturn-v-center-engine/
What happened was the Saturn V rocket experienced dangerous so-called “pogo” thrust oscillations, a problem NASA knew about. While a fix had been planned for Apollo 14, time did not permit its implementation on Apollo 13’s Saturn V.
“While a clerical error caused Apollo 13’s oxygen tank to explode,” said Woodfill, “because its heater design had not been updated for 65 volt operation, and the tank was a virtual bomb (see Part 1), similarly NASA’s failure to fix a known serious booster flaw should have destroyed Apollo 13.”
The Saturn V rocket had five J-2 engines, each producing 200,000 pounds of thrust, together creating the 1 million pounds of thrust needed for a mission to the Moon.
On previous Saturn flights, these pogo oscillations had occurred during launch. The phenomenon occurred as the fuel lines and structure of the rocket resonated at a common frequency. The resonance tended to amplify in force and potential destruction with each bounce of the “pogo” mechanism. So damaging was the phenomena on the unmanned Apollo 6 mission that an entire outer panel of the Saturn 5 ejected into space.
“The oscillations are like a jack hammer and it was so dreadful on Apollo 6 that it tore off a panel on the booster, and threatened the mission,” said Woodfill. “Apollo 6’s orbit was supposed to be circular, but because of the pogo effect and failure of second stage engines, the orbit became an elongated orbit of about 60 by 180 miles.”
Woodfill said if Apollo 13 had ended up in that type of orbit, it would have been bad but not fatal. However, Apollo 13 was a much different situation than Apollo 6.
The Apollo 6 mission carried a mock lunar lander of more modest mass than the “full-up” lander which Apollo 13 carried to orbit. With the added mass for Apollo 13, the pogo forces were suddenly a magnitude greater in intensity. A mission report said that the engine experienced 68g vibrations at 16 hertz, flexing the thrust frame by 3 inches (76 mm).
Woodfill said that if the center engine had continued running a few more seconds, the oscillations may have destroyed the vehicle. “That engine was pounding horizontally up and down, a quarter foot, at the rate of 16 times a second,” he said. “The engine had become a two ton sledge hammer, a deadly pogo stick of destruction, putting enormous forces on the supporting structures.”
What shut the engine down?
“It is, to this day, not fully understood, but it had something to do with fooling the engine’s thrust chamber pressure sensor that pressure was too low,” said Woodfill. He has studied the mission report, but says the complete analysis of why the engine shut down isn’t included.
“Though the shutdown command came from a low thrust chamber pressure sensor assessment, actually, the engine was operating correctly,” he said. ” The sensor had nothing to do with the pogo phenomenon. For some inexplicable reason, it was like something sucked the pressure out of the chamber and a sensor turned the engine off. But no one knows exactly why.”
Woodfill said those who later examined the situation said it was altogether lucky that the sensor shut down the engine. “Something intervened, stopping the engine from pounding its way from the mount into the fragile fuel tanks. This would have destroyed the Apollo 13 launch vehicle.”
13 MORE Things That Saved Apollo 13, part 6: The Mysterious Longer-Than-Expected Communications Blackout
https://www.universetoday.com/11992...longer-than-expected-communications-blackout/
